TONE AUTHENTIC GEORGIAN BAKERY & CUISINE
GRADE BThursday, May 2, 2024
Violations Cited
06F
Wiping Cloths Not Stored in Sanitizer
Wiping cloths not stored clean and dry, or in a sanitizing solution, between uses.
CONTAMINATION SPREAD: Dirty wiping cloths spread millions of bacteria across every surface wiped. Bacteria double every 20 minutes on damp cloths. One contaminated cloth can spread pathogens to 30+ surfaces, causing facility-wide contamination.
Store wiping cloths in sanitizer AT ALL TIMES between uses: 50-100ppm chlorine or 200-400ppm quaternary ammonium. Change solution when visibly dirty or every 4 hours. Use separate cloths for food contact vs non-food contact. Test sanitizer concentration every 2 hours.
04C
Bare Hand Contact with Ready-to-Eat Food
Food worker/food vendor does not use utensil or other barrier to eliminate bare hand contact with food that will not receive adequate additional heat treatment.
DIRECT CONTAMINATION: Hands carry 150+ bacterial species and 3,000-5,000 bacteria per square centimeter. Even 'clean' hands transfer millions of bacteria. Ready-to-eat foods receive no kill step. Bare hand contact is #1 factor in Norovirus outbreaks affecting 20 million Americans annually.
NO bare hand contact EVER with ready-to-eat foods. Use: Single-use gloves (change every hour and between tasks), Tongs/spatulas/spoons, Deli tissue/wax paper. Wash hands before donning gloves. Post signs. This is NON-NEGOTIABLE in NYC.
02G
Cold TCS Food Held Above 41°F
Cold TCS food item held above 41 °F; smoked or processed fish held above 38 °F; intact raw eggs held above 45 °F; or reduced oxygen packaged (ROP) TCS foods held above required temperatures except during active necessary preparation.
DANGER ZONE GROWTH: Between 41-70°F, E. coli doubles every 30 minutes. Salmonella doubles every 20 minutes at 70-90°F. After just 4 hours above 41°F, bacteria levels can cause severe illness including bloody diarrhea, kidney failure (E. coli), and typhoid fever (Salmonella).
Keep all cold TCS foods at 41°F or below (smoked fish 38°F, shell eggs 45°F). Monitor with calibrated thermometer every 2-4 hours. Ice baths must surround container to food level. Repair refrigeration immediately. DISCARD foods above 41°F for over 4 hours.
02B
Hot TCS Food Not Held at 140°F or Above
Hot TCS food item not held at or above 140 °F.
BACTERIAL MULTIPLICATION: At 120°F, Clostridium perfringens doubles every 10 minutes. Can reach illness-causing levels within 1 hour. This bacteria causes 1 million US cases annually with severe abdominal cramps and diarrhea lasting 24 hours. Hot holding violations responsible for 40% of restaurant outbreaks.
Maintain ALL hot foods at 140°F minimum. Check temperatures every 30 minutes for problem foods, every 2 hours otherwise. Use calibrated thermometers. Adjust equipment immediately if below 140°F. Reheat to 165°F if below temp for under 2 hours. DISCARD if below 140°F for over 2 hours.
Violations were cited in the following area(s).